145 - MiTo   1.4 16v TJet   ENGINE COMPARTMENT BUILT IN WIRING - R.R.   5505C26   

Detail     Detail

Removing ( Refitting )

See the Wiring Diagrams section for accurate identification of the electrical connections.

   Op. 7040A24 DASHBOARD CLOSURE LOWER TRIM - R.R.

   Op. 7040G20 BULB HOLDER FOR COMPARTMENT LIGHTING IN DASHBOARD - R.R.

   Op. 7040A31 DASHBOARD COMPARTMENT ASSEMBLY - R.R.

   Op. 5580C22 AIR BAG MODULE - PASSENGER SIDE - R.R

   Op. 5010C55 LOWER AIR DIFFUSER (ONE) LH OR RH - R.R

   Op. 7040A37 FUSE BOX COVER IN INSTRUMENT PANEL - R.R

   Op. 7040A82 SWITCH UNIT ON LEFT SIDE OF DASHBOARD - R.R.

- Follow the safety instructions for the following procedure.

   Op. 5580C18 AIR BAG MODULE - R+R

   Op. 4110A10 STEERING WHEEL - R+R FOR REPLACEMENT OR CHECKS

   Op. 7040A26 STEERING COLUMN TRIM - R+R

   Op. 5550A10 STALK UNIT ASSEMBLY - R+R

   Op. 5560B10 CONTROL PANEL - R+R

   Op. 5580E08 AERIAL FOR ELECTRONIC KEY (CODE) - R.R.

   Op. 5580C23 DRIVE SIDE KNEE PROTECTION AIR BAG MODULE R. R.

   Op. 5570T80 CAR RADIO EQUIPMENT - R+R

   Op. 5010C31 CENTRE AIR VENT IN DASHBOARD (ONE) LEFT OR RIGHT - R.R.

   Op. 7040A85 INSTRUMENT PANEL CENTRE FRAME - R.R.

   Op. 5570T49 BLUETOOTH ELECTRONIC CONTROL UNIT - R.R.

   Op. 5570T50 BLUETOOTH ELECTRONIC CONTROL UNIT MOUNTING - R.R.

   Op. 5010D56 SOLAR SENSOR - R.R. FOLLOWING ELECTRICAL SYSTEM CHECK

   Op. 7040H30 FRONT PILLAR TRIM (ONE), LEFT OR RIGHT - R.R.

   Op. 5040D15 CONTROL UNIT WITH KNOBS AND BUTTONS FOR DUAL ZONE AIR CONDITIONER - R.R.

   Op. 7040A10 DASHBOARD TRIM - R+R

- Drain the coolant.

   Op. 0010T84 AIR CONDITIONING SYSTEM REFRIGERANT - DEHYDRATING AND REPRESSURIZING

- Drain the engine coolant.

   Op. 0010T20 ENGINE COOLANT - CHANGE

- Work on both sides.

   Op. 7040A65 CONSOLE SIDE CLOSING (ONE) - R.R.

   Op. 3380A44 HANDBRAKE/LINKAGE PROTECTION - R+R

   Op. 7040L22 REAR COVER ON TUNNEL - R.R.

   Op. 2125C02 GEAR CONTROL LEVER OUTER GAITER R R

   Op. 7040L20 TUNNEL COVER - R.R

   Op. 7210E36 R.R. FRONT SIDE DOOR

   Op. 7040A98 INSTRUMENT PANEL TRIM SUPPORTING CROSSMEMBER - R.R. WITH DASHBOARD REMOVED

   Op. 5040C12 AIR CONDITIONING CASING - R.R. WITH DASHBOARD REMOVED

- Remove the wiper arms.

   Op. 5050B34 WINDSCREEN WIPER ASSEMBLY - R+R OR REPAIR

   Op. 7025A62 BONNET LID WEATHERSTRIP - R+R

   Op. 7210E22 R.R. WINDSCREEN BASE TRIM

   Op. 5050B38 FRONT WINDSCREEN WIPER ARM(S) COMPLETE WITH BLADE - R.R.

   Op. 1016A10 SOUND-PROOFING COVER - R.R

   Op. 1048A10 AIR FILTER ASSEMBLY - R.R.

   Op. 5530B10 BATTERY - R+R

   Op. 5530B52 BATTERY SUPPORT/DRIP TRAY - R.R

- Remove both side repeaters.

   Op. 5550C22 L/H OR R/H SIDE REPEATER (ONE) - R+R

   Op. 5550C54 BULB FOR ONE SIDE REPEATER UNIT LH OR RH - R.R

   Op. 7055B90 LEFT FRONT WHEEL ARCH LINER - R.R.

   Op. 7055B91 RIGHT FRONT WHEEL ARCH LINER - R.R.

   Op. 7210E10 R.R. FRONT BUMPER


Enlarge the image


1. Working in the front windscreen wiper housing, disconnect the connection (1a) for the rear windscreen wiper pipes (1b).

2. Working from inside the passenger compartment, extract part (2a) of the pipe, releasing it from the duct seal (2b).


Enlarge the image


1. Unscrew the bolts.

2. Remove the engine compartment junction unit cover.


Enlarge the image


1. Undo the nut and disconnect the electrical connection from the junction unit.

 

 

Description

 

Connector

 

1

 

JUNCTION UNIT

 

   See B001 JUNCTION UNIT

2. Release the electrical connection from the junction unit container seat.

3. Cut the wiring retaining band.

4. Raise the junction unit slightly releasing the retainers.


Enlarge the image


1. Disconnect the engine compartment wiring from the retaining bands.

2. Disconnect the electrical connections not yet disconnected for the engine compartment wiring.

Disconnect the windscreen wiper pipe connections in the area of the screen washer fluid reservoir.

3. Remove the engine compartment wiring, releasing it from the engine compartment side.


Enlarge the image


Refitting ( Removing )

- Check that the engine compartment wiring is not damaged and that the individual conductors are correctly fastened to the connections.

If necessary, carry out continuity tests.

- Place the engine compartment wiring in position, inserting it via the opening on the engine compartment side.

Fit the bulkhead seal in place and attach the retainers.

- Connect the windscreen wiper pipe connections in the area of the screen washer fluid reservoir.

- Connect the engine compartment wiring electrical connections that can be connected.

- Connect the engine compartment wiring to the retaining bands.

- Position the engine compartment junction unit and attach the retainers.

- Fit the wiring retaining band.

- Attache the electrical connection in the junction unit container seat.

- Connect the electrical connection to the junction unit and screw in the nut.

- Position the junction unit container cover.

- Screw in the bolts.

1. Working from inside the passenger compartment, fit part (1a) of the pipe for the rearscreen wiper, attaching it to the duct seal (1b).

2. Working in the front windscreen wiper housing, connect the connection (2a) for the rear windscreen wiper pipes (2b).

    Op. 7210E10 R.R. FRONT BUMPER

    Op. 7055B91 RIGHT FRONT WHEEL ARCH LINER - R.R.

    Op. 7055B90 LEFT FRONT WHEEL ARCH LINER - R.R.

    Op. 5550C54 BULB FOR ONE SIDE REPEATER UNIT LH OR RH - R.R

    Op. 5550C22 L/H OR R/H SIDE REPEATER (ONE) - R+R

- Refit both side repeaters.

    Op. 5530B52 BATTERY SUPPORT/DRIP TRAY - R.R

    Op. 5530B10 BATTERY - R+R

    Op. 1048A10 AIR FILTER ASSEMBLY - R.R.

    Op. 1016A10 SOUND-PROOFING COVER - R.R

    Op. 5050B38 FRONT WINDSCREEN WIPER ARM(S) COMPLETE WITH BLADE - R.R.

    Op. 7210E22 R.R. WINDSCREEN BASE TRIM

    Op. 7025A62 BONNET LID WEATHERSTRIP - R+R

    Op. 5050B34 WINDSCREEN WIPER ASSEMBLY - R+R OR REPAIR

- Remove the wiper arms.

    Op. 5040C12 AIR CONDITIONING CASING - R.R. WITH DASHBOARD REMOVED

    Op. 7040A98 INSTRUMENT PANEL TRIM SUPPORTING CROSSMEMBER - R.R. WITH DASHBOARD REMOVED

    Op. 7210E36 R.R. FRONT SIDE DOOR

    Op. 7040L20 TUNNEL COVER - R.R

    Op. 2125C02 GEAR CONTROL LEVER OUTER GAITER R R

    Op. 7040L22 REAR COVER ON TUNNEL - R.R.

    Op. 3380A44 HANDBRAKE/LINKAGE PROTECTION - R+R

    Op. 7040A65 CONSOLE SIDE CLOSING (ONE) - R.R.

- Repressurize the engine coolant.

    Op. 0010T20 ENGINE COOLANT - CHANGE

- Repressurize the coolant.

    Op. 0010T84 AIR CONDITIONING SYSTEM REFRIGERANT - DEHYDRATING AND REPRESSURIZING

    Op. 7040H30 FRONT PILLAR TRIM (ONE), LEFT OR RIGHT - R.R.

    Op. 5010D56 SOLAR SENSOR - R.R. FOLLOWING ELECTRICAL SYSTEM CHECK

    Op. 5040D15 CONTROL UNIT WITH KNOBS AND BUTTONS FOR DUAL ZONE AIR CONDITIONER - R.R.

    Op. 5570T50 BLUETOOTH ELECTRONIC CONTROL UNIT MOUNTING - R.R.

    Op. 5570T49 BLUETOOTH ELECTRONIC CONTROL UNIT - R.R.

    Op. 7040A85 INSTRUMENT PANEL CENTRE FRAME - R.R.

    Op. 5010C31 CENTRE AIR VENT IN DASHBOARD (ONE) LEFT OR RIGHT - R.R.

    Op. 5570T80 CAR RADIO EQUIPMENT - R+R

    Op. 5580C23 DRIVE SIDE KNEE PROTECTION AIR BAG MODULE R. R.

    Op. 5580E08 AERIAL FOR ELECTRONIC KEY (CODE) - R.R.

    Op. 5560B10 CONTROL PANEL - R+R

    Op. 5550A10 STALK UNIT ASSEMBLY - R+R

    Op. 7040A26 STEERING COLUMN TRIM - R+R

    Op. 4110A10 STEERING WHEEL - R+R FOR REPLACEMENT OR CHECKS

    Op. 4110A10 STEERING WHEEL - R+R FOR REPLACEMENT OR CHECKS

    Op. 5580C18 AIR BAG MODULE - R+R

    Op. 7040A82 SWITCH UNIT ON LEFT SIDE OF DASHBOARD - R.R.

    Op. 7040A37 FUSE BOX COVER IN INSTRUMENT PANEL - R.R

    Op. 5010C55 LOWER AIR DIFFUSER (ONE) LH OR RH - R.R

    Op. 5580C22 AIR BAG MODULE - PASSENGER SIDE - R.R

    Op. 7040A31 DASHBOARD COMPARTMENT ASSEMBLY - R.R.

    Op. 7040G20 BULB HOLDER FOR COMPARTMENT LIGHTING IN DASHBOARD - R.R.

    Op. 7040A24 DASHBOARD CLOSURE LOWER TRIM - R.R.